U.S. Route 12 in Illinois Information
US 12 highlighted in red
|Maintained by IDOT and CDOT|
|Length||85.14 mi  (137.02 km)|
|West end||US 12 near Richmond|
|East end||US 12 / US 20 / US 41 in Chicago|
|Counties||McHenry, Lake, Cook|
U.S. Route 12 (US 12) in the U.S. state of Illinois is an arterial highway that runs northwest to southeast through the Chicago metropolitan area. It enters Illinois at the Wisconsin border north of Richmond, and exits into Hammond, Indiana from Chicago near the foot of the onramp to the Indiana Toll Road ( Interstate 90, I-90); as it exits Illinois, the route is also concurrent with US 20 and US 41. Within Illinois, US 12 runs for a distance of 85.14 miles (137.02 km). 
The westernmost portion of US 12 in Illinois runs south from the Wisconsin border, between Genoa City, Wisconsin and Richmond. North of Genoa City, US 12 is a four-lane limited-access freeway. In Illinois, it reverts to a two-lane, undivided surface road prior to a traffic light with Illinois Route 173 (IL 173) north of Richmond. South of Richmond, through traffic on US 12 must turn left at IL 31 to continue. until the Fox Lake area; at that point it becomes a four-lane divided highway, with occasional interchanges.
US 12 runs concurrently with IL 59 south of Fox Lake at an access-controlled interchange, and then intersects with IL 134 at a traffic light. In Volo, there is a traffic light with IL 120, but then reverts to an expressway, with interchanges for IL 176 (Liberty Street) and IL 59. From the state line to this point, US 12 is also marked as the main route for the Fox River Valley, which continues south on IL 59.
In Lake Zurich, US 12 picks up the name Rand Road, named so for a former name of the city of Des Plaines.  There is also an intersection with IL 22 (Main Street). US 12 proceeds towards Deer Park and Kildeer before entering Cook County in Palatine. US 12 then briefly overlaps IL 53 between Hicks Road and IL 68 (Dundee Road) in northeast Palatine. At the expressway portion of IL 53, US 12 traffic can only access southbound IL 53.
From IL 53, US 12 travels through the heavily populated areas of Arlington Heights and Mount Prospect, intersecting with IL 83 (Elmhurst Road) in Mount Prospect. US 12 enters the Des Plaines area at IL 58 (Golf Road), and joins with US 45 (Des Plaines River Road) north of downtown at a complex intersection. Westbound US 12 traffic is required to cross US 45 twice (on Elk Boulevard) to access Rand Road, as all turns are prohibited from US 45 to US 12. Eastbound US 12 joins with southbound US 45.
In Des Plaines, US 12/US 45 separates, as southbound traffic travels on Graceland Avenue, while northbound traffic runs one block east. In downtown Des Plaines, US 12/45 has a major intersection with US 14 (Miner Street) at a busy at-grade crossing with the Harvard Subdivision of the Union Pacific Railroad.
After turning south from Des Plaines, US 12/US 45 forms a major north–south artery through the western suburbs. North of Cermak Road the route is known as Mannheim Road, while south of Cermak Road it is known as La Grange Road. The distance from the intersection of US 12/US 45 and US 14 in Des Plaines to the US 12/US 20/US 45 split in Hickory Hills is 9.97 miles (16.05 km).
US 12/US 45 runs through various streets in Des Plaines before following Mannheim Road north of O'Hare International Airport. This routing also closely parallels the north-south orientation of the Canadian National Railway rail line. US 12/US 45 intersects IL 72 (Higgins Road) at the northeast corner of the airport, and then travels south along the eastern border of the airport. There is a full interchange with I-190 for passenger airport traffic. At the southeast corner of the airport, a signalized intersection terminates a brief expressway portion of 19 (Irving Park Road).
South of Irving Park Road, US 12/US 45 travels beneath the Bensenville Bridge on I-294 ( Tri-State Tollway) while also crossing over the Franklin Park rail yard; however, there is no interchange with I-294 at this point. This rail line also carries Metra Milwaukee District West trains. In Melrose Park, US 12/US 45 has a grade-separated intersection with IL 64 (North Avenue), a major east–west artery west of Chicago. About a mile (1.6 km) south, US 20 joins with US 12/US 45 to form a triple concurrency over the Union Pacific Railroad's Proviso Yard as well as the mainline tracks of the Geneva Subdivision.
US 12/US 20/US 45 continues south and becomes the eastern endpoints of two state routes: IL 56 in Bellwood and IL 38 in Westchester. In between lies a full intersection with I-290 (Eisenhower Expressway). In downtown La Grange, US 12/US 20/US 45 intersects with US 34 (Ogden Avenue), making it the only location in the Chicago area (and possibly the state of Illinois) where four U.S. Routes intersect.[ citation needed] In addition, there is a level-grade crossing with BNSF Railway tracks very near the intersection, which leads to large amounts of delays.[ citation needed]
South of La Grange, US 12/US 20/US 45 has a full interchange with I-55 (Stevenson Expressway). It then crosses the Des Plaines River and Chicago Sanitary and Ship Canal before a complex interchange with IL 171 ( Archer Avenue). A ramp from I-294 to US 12/US 20/US 45 formerly existed, but was removed in the late 1990s due to safety concerns. Just south of the Tri-State Tollway, US 12/US 20/US 45 becomes southbound 96th Avenue, passing through Cook County Forest Preserves for nearly two miles (3.2 km) before US 12/US 20 split from US 45 onto eastbound 95th Street.
After turning off the US 45 routing in Hickory Hills, US 12/US 20 runs east on 95th Street for 16.31 miles (26.25 km)—combined with a concurrency with US 41, this segment runs for an additional 18.02 miles (29.00 km) into the state of Indiana.
The 95th Street portion of US 12/US 20 is a four-lane undivided arterial surface street through the southern suburbs of Palos Hills, Bridgeview, Oak Lawn and Evergreen Park. It serves the main commercial areas of these communities and the Chicago south side neighborhoods of Beverly, Washington Heights, Roseland, Burnside, Pullman, Calumet Heights, South Deering and East Side.
In Bridgeview, US 12/US 20 has interchanges with I-294 and IL 43 (Harlem Avenue). In Oak Lawn, it intersects IL 50 (Cicero Avenue). Further east, in Chicago, US 12/US 20 nearly intersects IL 1 ( Halsted Street); IL 1 technically terminates at I-57 a half mile (0.8 km) south. US 12/US 20 then has an interchange with I-94 ( Dan Ryan Expressway) just north of the I-57/I-94 split. Shortly after bridging the Calumet River, US 12/US 20 joins with US 41.
The concurrent US 12/US 20/US 41 combination runs south on Ewing Avenue beneath the Chicago Skyway, narrowing from two northbound and southbound lanes to one northbound and one southbound lane before turning onto Indianapolis Boulevard, a six-lane divided highway. At 104th Street, there is a traffic light for a relocated offramp (from 106th Street) from the Chicago Skyway to Indianapolis Boulevard. The southbound onramp to the Indiana Toll Road is still located at 106th Street.
The Illinois portion of US 12/US 20/US 41 terminates beneath the I-90 bridge over Indianapolis Boulevard; this is also where the Chicago Skyway becomes the Indiana Toll Road.
In 1928, US 12 followed its current route south from Wisconsin into Richmond. It then continued straight on what is now IL 31 to Crystal Lake, and then ran along what is now US 14 into Chicago. This route began to be depicted on Chicago maps in 1932 along the Northwest Highway, Foster Avenue, Lake Shore Drive, South Parkway (now most likely the 57th Street / Cornell Avenue combination), Stony Island Avenue and 95th Street.
From 1928 to 1929, the section between the Wisconsin state line to Crystal Lake was being constructed; this segment was designated Temporary U.S. Route 12 at the time.
In 1938, US 12 was moved north off the US 14 routing to the current routing to Des Plaines. In addition, US 12 was moved to what is now Mannheim Road, La Grange Road and 95th Street. The former US 12 became City US. Route 12.  
In 1939, US 12 was moved to a bypass around Lake Zurich and widened to four lanes. Old Rand Road was the name given to the former US 12 alignment.  The original 1939 E.J.& E. RR. 4 span concrete bridge over the US 12 bypass remains in Lake Zurich with telegraph poles visible on the bridge. The original pot hole full 1939 asphalt pavement has since been resurfaced including replacing with concrete lanes and widening from through lanes to six through lanes between IL 22 and Ela Road in a project in 2007.
In the early 1950s, US 12 was moved to a bypass around Wauconda and widened to four lanes extending to IL 120 in Volo. Old Rand Road was the name given to the former US 12 alignment.  The original pothole-full 1950s asphalt pavement with double yellow lines visible in the west bound lanes between Old McHenry Road and Old Rand Road has since been resurfaced in 2013. Mature trees in the interchange grassy areas and 1950s style motels remain in Wauconda.
In the late 1950s, US 12 was widened to four lanes extending to Fox Lake.  Mature trees lining the frontage roads and 1950s style motels and diners remain in Fox Lake. US 12 in Illinois has not been widened further northwest since then.
There were no further changes to the US 12 routing until 1960, when City US 12 became Business U.S. Route 12. In 1963, US 12 was moved onto the Chicago Skyway and became Toll Business U.S. Route 12 until 1968, when all Business US 12 designations were dropped.  
In Illinois, the highway has been designated as the Iron Brigade Memorial Highway to honor the Civil War Union Army unit,  a designation it also has in Michigan,  Indiana,  and Wisconsin. 
|McHenry||||0.0||0.0||US 12 west – Lake Geneva||Continuation into Wisconsin|
|Richmond||1.1||1.8||IL 173 (Kenosha Street)|
|||3.1||5.0||IL 31 south (Richmond Road) – McHenry||Northern terminus of IL 31|
|Lake||Fox Lake||13.0||20.9||IL 59 north||Western end of IL 59 concurrency; westbound exit and eastbound entrance|
|13.5||21.7||IL 134 east (Big Hollow Road)||Western terminus of IL 134|
|Volo||16.8||27.0||IL 120 (Belvidere Road)|
|Wauconda||21.4||34.4||IL 176 (Liberty Street)||Diamond interchange|
|22.0||35.4||IL 59 south||Eastern end of IL 59 concurrency; westbound entrance and eastbound exit|
|Lake Zurich||27.3||43.9||IL 22 (West Main Street)||Red light camera enforcement intersection|
|Cook||Palatine||32.2||51.8||IL 53 north (Hicks Road)||Western end of IL 53 concurrency|
|33.0||53.1||IL 53 south / IL 68 (Dundee Road)||Eastern end of IL 53 concurrency|
|Arlington Heights||34.2||55.0||IL 53 south||Partial diamond interchange|
|Mount Prospect||39.0||62.8||IL 83 (Elmhurst Road, Main Street)|
|Des Plaines||41.8||67.3||IL 58 (Golf Road)|
|42.6||68.6||US 45 north (Des Plaines River Road)||Western end of US 45 concurrency|
|43.1||69.4||US 14 (Miner Street, Northwest Highway)|
|46.4||74.7||IL 72 (Higgins Road)||Red light camera enforcement intersection|
|Rosemont||47.7||76.8||I-190 ( Kennedy Expressway) – Chicago, O'Hare International Airport||I-190 exit 2|
|Schiller Park||48.7||78.4||IL 19 (Irving Park Road)|
|Stone Park||53.0||85.3||IL 64 ( North Avenue)|
|Berkeley||53.7||86.4||US 20 west ( Lake Street)||Western end of US 20 concurrency|
|Bellwood– Hillside line||54.8||88.2||IL 56 west (Washington Boulevard)||Eastern terminus of IL 56|
|Hillside– Westchester line||55.6||89.5||I-290 / IL 110 (CKC) (Dwight D. Eisenhower Expressway) – Chicago||I-290 exit 17|
|56.1||90.3||IL 38 west ( Roosevelt Road)||Eastern terminus of IL 38|
|La Grange||59.3||95.4||US 34 ( Ogden Avenue)|
|Countryside||62.0||99.8||Historic US 66 (Joliet Road)|
|Hodgkins||63.2||101.7||I-55 (Aldai E. Stevenson Expressway) – Chicago, St. Louis||I-55 exit 279|
I-294 south (Tri-State Tollway) / IL 171 north ( Archer Avenue) / To 79th Street – Indiana
|Interchange; left exit eastbound|
|64.9||104.4||IL 171 south ( Archer Avenue)||Interchange|
|Hickory Hills||66.5||107.0||US 45 south ( La Grange Road south)||Eastern end of US 45 overlap|
I-294 (Tri-State Tollway) – Wisconsin, Indiana
|Tolled; I-294 exit 17|
|69.2||111.4||IL 43 ( Harlem Avenue)||Cloverleaf interchange|
|Oak Lawn||71.7||115.4||IL 50 ( Cicero Avenue)|
|To IL 1 ( Halsted Street) / I-94 east (Bishop Ford Freeway) / I-57|
|80.3||129.2||Stony Island Avenue||Northern terminus of Stony Island Avenue expressway (southbound); at-grade street northbound|
|82.8||133.3||US 41 north (Ewing Avenue north)||Northern end of US 41 overlap|
|84.3||135.7||I-90 west ( Chicago Skyway) / Toll Bridge||Tolled; signed as "To I-90 west"; access to I-90 east is in Indiana; I-90 exit 107|
|84.4||135.8||US 12 / US 20 east / US 41 south (Indianapolis Boulevard) – Hammond||Continuation into Indiana|
|1.000 mi = 1.609 km; 1.000 km = 0.621 mi|
- Carlson, Rich (March 15, 2005). "Routes 1 thru 20". Illinois Highways Page. Retrieved June 4, 2006.[ self-published source]
- Illinois Technology Transfer Center (2007). "T2 GIS Data". Illinois Department of Transportation. Retrieved November 8, 2007.
- "History". City of Des Plaines. May 26, 2006. Retrieved June 5, 2006.
- Illinois Road Map (Map). c. 1:950,000 and c. 1:1,110,000. Illinois Automobile Department. 1936. Retrieved March 20, 2015 – via Illinois State Library.
- Illinois Road Map (Map) (1939–40 ed.). c. 1:950,000 and c. 1:1,110,000. Illinois Automobile Department. 1939. Retrieved March 20, 2015 – via Illinois State Library.
- Illinois Road Map (Map). c. 1:950,000 and c. 1:1,110,000. Illinois Automobile Department. 1940. Retrieved March 20, 2015 – via Illinois State Library.
- Illinois: Official Highway Map (Map). 1:805,000. Illinois Division of Highways. 1955. Retrieved March 20, 2015 – via Illinois State Library.
- Illinois Road Map (Map). 1:805,000. Illinois Division of Highways. 1957. Retrieved March 20, 2015 – via Illinois State Library.
- Illinois: Official Highway Map (Map). 1:790,000. Illinois Division of Highways. 1960. Retrieved March 20, 2015 – via Illinois State Library.
- Illinois: Official Highway Map (Map). 1:772,500. Illinois Division of Highways. 1968. Retrieved March 20, 2015 – via Illinois State Library.
- RoadDog (September 4, 2008). "US 12 in Illinois Gets New Name". American Road Forum. Americanroadmagazine.com. Retrieved August 15, 2012.[ self-published source][ unreliable source?]
- Michigan Legislature (October 26, 2001). "Section 250.1048". Michigan Compiled Laws. State of Michigan. Retrieved August 15, 2012.
- "State Farm Sponsorship of Hoosier Helpers". Indiana Department of Transportation. June 16, 2009. Retrieved August 15, 2012.
- "Commemorative Highways and Bridges". Wisconsin Department of Transportation. June 4, 2010. Retrieved August 15, 2012.
- Media related to U.S. Route 12 in Illinois at Wikimedia Commons
|U.S. Route 12|